Send a Message

Contact Us

Company Address

Zhengzhou, China.

Utilization of waste glass as sand replacement in cement

2016-7-20  Utilization of waste glass as sand replacement in cement mortar Nurhayat Degirmenci a, Arin Yilmaz b* & Ozge Andic Cakir c aDepartment of Architecture, bDepartment of Civil Engineering Engineering and Architecture Faculty, Balikesir University, 10145 Balikesir, Turkey

Utilization of waste glass as sand replacement in

Utilization of waste glass as sand replacement in cement mortar Nurhayat Degirmenci a,Arin Yilmaz b * & Ozge Andic Ca kir c a Department of Architecture, b Department of

Sustainable utilization of crushed waste glass as sand

2019-10-1  This research investigates the utilization of crushed waste glass as partial and complete replacement for natural sand in cement mortar for the production of interlocking paving stones (IPS). The waste glass was varied at various percentage proportions by weight to replace the fine aggregate in the cement mortar mixes.

Utilizing Waste Recycled Glass as Sand/Cement

2020-12-4  Two levels of replacement for the recycled glass sand to replace the na tural sand wer e used in this study, namely 50% and 100%, while single replacement of

(PDF) The Usage of Glass Waste as Cement Replacement

The objective was to make use of the combination of waste glass powder (GP) and rice husk ash (RHA) as replacement for Portland cement. Hybrid mixtures containing 0-20% GP and 0

Utilization of waste glass powder as a partial

In terms of fly ash replacement for 10% of cement, increased compressive strength results of WGP were observed at pozzolanic reaction period compared with those of glass powder for 20% of cement.

Waste glass powder as partial replacement of cement

2017-6-1  Trial mix design were conducted to obtain the target strength of 35 MPa at 28 days with a workability of 100–125 mm as per American Concrete Institute ACI 211.1 (ACI, 2009).The glass powder replacement in cement was varied (0–25%). Mix proportion of concrete is shown in Table 6.Firstly, stone chips and sand were dry mixed for a minute.

Utilization of waste glass powder in the production of

2016-10-15  The test results of concrete compressive strength for mixes with glass powder as cement replacement for individual samples, mean strength, standard deviation and coefficient of variation are given in Table 7. The effect of using glass powder as cement replacement on cube concrete compressive strength (fc) at 7, 28 and 56 days is shown in Fig. 11.

Researchers have discovered how to make concrete

2019-6-12  "We have found that substituting sand with ground recycled glass makes the polymer concrete stronger and is a sustainable use of one of the major

UTILIZATION OF WASTE GLASS IN CONCRETE

Utilization of waste glass is used as an aggregate, resulting in obvious difference in the structure of the concrete including reduced bond between the aggregate and the cement paste. The

Sustainable utilization of crushed waste glass as sand

This research investigates the utilization of crushed waste glass as partial and complete replacement for natural sand in cement mortar for the production of interlocking paving stones (IPS). The waste glass was varied at various percentage proportions by weight to replace the fine aggregate in the cement

(PDF) Utilization of Waste Glass as Partial

The aim of this study is to improve the strength of concrete made by partial replacement of fine aggregate with waste glass. The fine aggregate was replaced by waste glass as (0-40%) with dosage

Effective Utilization of Waste Glass as Cementitious

2020-2-5  480, 500), replacement rate (glass/cement (G/B), 0%,10%, 20%, 30%), and color of glass powder (green and colorless). Finally, glass culets were ground and graded into waste glass sand (WGS) according to American Society for Testing and Materials (ASTM) C1260 [36], and then the potential ASR expansion was tested.

(PDF) Utilization of Glass Powder in Cement Concrete

Utilization of Glass Powder in Cement Concrete Paver Blocks. sheltered and practical different option for sand utilized as a part of concrete. Amid the most recent decade, it has been perceived that sheet glass waste is of extensive volume and is expanding year by year in the shops, development zones and manufacturing plants.Utilizing waste

Valorization of Crushed Glass as a Potential

The bricks were made with 1:1 proportion of fly ash and sand stabilized with 20 % cement. Crushed glass was used as replacement for the fine aggregate in increments of 10 % up to 40 % wherein the sand was completely replaced with crushed glass.

Utilization of waste glass in translucent and

2020-9-21  Utilization of waste glass in translucent and photocatalytic concrete broken glass could be used as sand replacement in con-crete pavement, asphalt additive and road filler. Moreover, glass also washed glass fractions are used. The cement used in this research CEM I 52.5 N white, is a low-alkali cement

Partial Replacement of Fine Aggregate by Glass

Utilization in concrete is a motivating risk for the economy on waste disposal sites and conservation. This project examines the likelihood of utilization of GP in fine mixture replacement in concrete. Natural sand will be part replaced (0% 40%) with GP in concrete.

AN EXPERIMENTAL IVESTIGATION OF PARTIAL

2018-11-3  out the strenghth of concrete containing waste glass powder as a partial replacement of cement for concrete.Cement replacement by glass powder ranging from 5% to 40% increment of 5% have been studied.A test was conducted for testing compressive strength and flexural strength at the age of 7,28 and 90 days and compared with those of conventional

Potential utilization of LD slag and waste glass in

2020-1-1  Waste glass is highly endorsed for the partial replacement of cement . Nurhayat et al. have worked on the utilization of waste glass for cement mortar where it replaces sand . Expansion of ASR (alkali silica reaction) which is a measure issue in concrete that has been diminished due to the use of colored waste glass instead of sand.

PAPER OPEN ACCESS The Utilization of Recycled

or full replacement of sand show the main problems with its use such as higher water absorption due to high content of cement mortar and unwanted and undefined impurities. The water absorption of recycled aggregate concrete with partial replacement of sand and gravel of RCA is higher in comparison with conventional concrete.

Sustainable utilization of crushed waste glass as sand

This research investigates the utilization of crushed waste glass as partial and complete replacement for natural sand in cement mortar for the production of interlocking paving stones (IPS). The waste glass was varied at various percentage proportions by weight to replace the fine aggregate in the cement

Effective Utilization of Waste Glass as Cementitious

2020-2-5  480, 500), replacement rate (glass/cement (G/B), 0%,10%, 20%, 30%), and color of glass powder (green and colorless). Finally, glass culets were ground and graded into waste glass sand (WGS) according to American Society for Testing and Materials (ASTM) C1260 [36], and then the potential ASR expansion was tested.

Utilization of waste glass in the improvement of

2020-7-16  Utilization of waste glass in the improvement of concrete performance: A mini review Experimental investigation on strength of glass powder replacement by cement in concrete with different dosages. Nounu, G (2008) Properties of concrete contains mixed colour waste recycled glass as sand and cement replacement.

Effective Utilization of Waste Glass as Cementitious

The purpose of this study is to investigate the availability of waste glass as alternative materials in sustainable constructions. Collected waste glass was ground into waste glass powder (WGP) with similar particle size distribution as Portland cement (PC) and waste glass sand (WGS) with similar grade as sand. The compressive strength was investigated through the Taguchi test to evaluate the

Sustainable Use of Recycled Glass Powder as Cement

A.Z.M. Muhammad Nazrin Akmal, F Mat Yahaya, H Mohd Hanafi, and Z Nur Azzimah, Utilization of fly ash as partial sand replacement in oil palm shell lightweight aggregate concrete. [68] R-U-D. Nassar, and P. Soroushian, "Strength and durability of recycled aggregate concrete containing milled glass as partial replacement for cement", Constr. Build.

Utilization of Glass Fibers in Concrete: A Review

2020-3-27  cement replacement of fine glass powder gives as the most optimal strength results because with this replacement the decrease in strength[5]. Prasath C. et al., 2014 have done experimentally on high-performance concrete by using Glass Fiber and Foundry sand. For

AN EXPERIMENTAL IVESTIGATION OF PARTIAL

2018-11-3  out the strenghth of concrete containing waste glass powder as a partial replacement of cement for concrete.Cement replacement by glass powder ranging from 5% to 40% increment of 5% have been studied.A test was conducted for testing compressive strength and flexural strength at the age of 7,28 and 90 days and compared with those of conventional

PAPER OPEN ACCESS The Utilization of Recycled

or full replacement of sand show the main problems with its use such as higher water absorption due to high content of cement mortar and unwanted and undefined impurities. The water absorption of recycled aggregate concrete with partial replacement of sand and gravel of RCA is higher in comparison with conventional concrete.

The Utilization Of Crushed Stone Dust As A

In the crusher machine after crushing of stone the product retained known as crushed stone dust. If can be used as a fine aggregate in cement concrete as a replacement of sand it may be replace fully or partially as a percentage of 20%, 40%, 50%, 60%, 80% of gives the higher strength as that of sand gives with the help of suitable admixtures.

Replacement of Sand with Bauxite Mining Waste in

- A.S. Gaur, S. Kumar, Effect of Partial Replacement of Cement by Ground-Granulated Blast-Furnace Slag and Fine Aggregate by Marble Slurry on Properties of Concrete. Am. J. Eng. Res. 6(1) (2017) 28-31. I. Mpae, Utilization of Bauxite Tailings as partial replacement of sand in blocks, MPhil Thesis, University of Education, Winneba, 2014.